Product ID:ZEP FS FORMULA 386, 2441
MSDS Date:11/20/1997
FSC:7930
NIIN:01-423-1187
Status Code:A
MSDS Number: CLCBJ

ZEP MFG CO DIV OF NATIONAL SERVICE INDUSTRIES

1310 SEABOARD INDUSTRIAL BLVD NW
ATLANTA, GA 30301
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Cage: 27674

ZEP MANUFACTURING COMPANY

2015 ATLANTA, GA 30318 US

Telephone: 877-428-9937

Cage: 27674

PHOSPHORIC ACID

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 20-30%

OSHA PEL 1 MG/M3

ACGIH TLV: 0.25 PPM;STEL 3MG/M3

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

QUATERNARY AMMONIUM CHLORIDES, BLEND OF ALKYL

CAS: 68391-01-5

RTECS: 1004358AD

Fraction By Weight: 10-20%

Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MSDS DATA PERTAINS TO PRODUCT AS
DISPENSED FROM CONTAINER. ADVERSE HEALTH EFFECTS NOT EXPECTED UNDER
RECOMMENDED USE CONDITIONS (DILUTED) SO LONG AS PRESCRIBED SAFETY
PRECAUTIONS ARE PRACTICED. ACUTE: CORROSIVE TO SKIN/EYES ON
CONTACT. LIQUID/SPRAY MISTS MAY PRODUCE TISSUE DAMAGE, PARTICULARLY
ON MUCOUS MEMBRANES OF EYES/MOUTH/RESPIRATORY TRACT. EYE:PERMANENT
DAMAGE. SKIN:BURNS. INHAL: SEVERE IRRI TATION OF RESPIRATORY TRACT:
COUGHING, CHOKING, SHORTNESS OF BREATH. CHRONIC: REPEATED/PROLONGED
CONTACT: EYE IRRITATION; SEVERE SKIN IRRITATION; CHRONIC REPIRATORY
TRACT IRRITATION LEADING TO FREQUEN T ATTACKS OF BRONCHIAL
INFECTION.

First Aid:IMMED FLUSH CONTAM SKIN W/PLENTY OF WATER FOR @ LEAST 15 MIN.
GET MED ATTEN IF IRRIT DEVELOPS. EYES: IMMED FLUSH EYES W/PLENTY OF
WATER FOR @ LEAST 15 MIN,OCCASIONALLY LIFT UPPER & LOWER LIDS. GET
MED ATTEN @ ONCE. INHALE: MOVE EXPOSED PERSON TO FRESH AIR. IF
IRRIT PERSISTS, GET MED ATTEN PROMPTLY. INGEST: DO NOT INDUCE
VOMITING. IF VICTIM IS CONSCIOUS GIVE LOTS OF WATER TO DRINK. GET
MED AT ONCE.

Flash Point Method:TCC
Flash Point:NONE
Extinguishing Media:NON COMBUSTIBLE
Fire Fighting Procedures:NONE
Unusual Fire/Explosion Hazard:NONE

Spill Release Procedures:OBSERVE SAFETY PROCEDURE IN SECT 4 & 9 DURING
CLEAN-UP. ABSORB SPILL ON INERT ABSORBENT MATERIAL (EG ZEP-O-ZORB).
PICK UP & PLACE IN CLEAN D.O.T. SPECIFICATION CNTNR FOR DISPOSAL.
WASH AREA CLEAN WITH A DETERGENT SOLUTION AND THEN RINSE WELL
W/WATER.

Handling and Storage Precautions:*MONTH MAY BE DISPOSED IN CHEMICAL OR
INDUSTRIAL WASTE LANDFILL, IF EFFLUENT IS ULTIMATELY TREATED BY A
PUBLICLY OWNED TRATMENT WORKS, NEUTRALIZATION OF SPENT TANK
SOLUTIONS W/ SUBSEQUENT DISCHARGE T O SEWERS MAY BE POSSIBLE.
CONSULT LOCAL/STATE/FED AGENCIES FOR PROPER DISPOSAL METHOD IN YOUR
AREA.
Other Precautions:STORE TIGHTLY CLOSED CONTAINER IN DRY AREA AT TEMPS
BETWEEN 40 - 120 F. STORE AWAY FROM HIGHLY ALKALINE
PRODUCTS/OXIDIZING COMPOUNDS. KEEP AWAY FROM SKIN/EYES. PROMPTLY
REMOVE CONTAMINATED CLOTHING/SH OES & THOROUGHLY CLEAN BEFORE
REUSE. KEEP OUT OF REACH OF CHILDREN.

Respiratory Protection:NO SPECIAL MEASURES ARE REQUIRED.
Ventilation:IF VAPORS ARE DETECTED, VENTILATE WORK AREA BY OPENING
WINDOWS AND USING EXHAUST FANS.
Protective Gloves:WEAR NEOPRENE/NITRILE/NAT RUBBER GLOVES.
Eye Protection:TIGHT-FITTING SAFETY GLASSES OR GOGGLES*
Other Protective Equipment:*ESPECIALLY WHEN WEARING CONTACT LENSES.
Work Hygienic Practices:CLOTHING/SHOES WHICH BECOME CONTAMINATED WITH
SUBSTANCE SHOULD BE REMOVED PROMP AND NOT REWORN UNTIL THOROUGHLY
CLEANED.
Supplemental Safety and Health
STORE TIGHTLY CLOSED CONTAINER IN DRY AREA AT TEMPS BETWEEN 40-120 F.
STORE AWAY FROM HIGHLY ALKALINE PRODUCTS & OXIDIZING COMPOUNDS.
KEEP OUT OF REACH OF CHILDREN.

Boiling Pt:B.P. Text:212F,100C
Spec Gravity:1.17
pH:<1.5
VOC Grams/Liter:.13
Evaporation Rate & Reference:.75 (WATER=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR, RED LIQUID WITH A QUAT-TYPE ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG ALKALIS AND OXIDIZING AGENTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
AMMONIA, OXIDES OF NITROGEN.

Waste Disposal Methods:LIQUIDS CAN'T BE SENT TO LANDFILLS UNLESS SOLID.
UNUSABLE PROD & SOME COLLECTED, SPENT USE-DILUTIONS MAY REQUIRE
DISPOSAL AS HAZ WASTE AT A PERMITTED TREATMENT/STORAGE/DISPOSAL
FACILITY. MOST STATES H AZ WASTES IN TOTAL AMOUNTS OF 220 LBS OR
LESS PER*

SARA Title III Information:PHOSPHORIC ACID
State Regulatory Information:EPA TSCA CHEMICAL INVENTORY: ALL
INGREIDENTS ARE LISTED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.